Abstract
Objectives: The effects of cement dust exposure on acute respiratory health were assessed among 51 high exposed and 33 low exposed male cement workers. The ability of the questionnaire to diagnose acute decrease in ventilatory function was also assessed. Methods: Acute respiratory symptoms were recorded by interview using a structured optimal symptom score questionnaire. Peak expiratory flow (PEF) was measured preshift and postshift for each worker with a Mini-Wright PEF meter. Personal respirable dust (n=30) and total dust (n=15) were measured with 37-mm Cyclone and 37-mm closed-faced Millipore cassette. Twenty-nine workers had concurrent respirable dust, PEF and questionnaire on the same day. Results: The geometric means of personal respirable dust and total dust among high exposed were 4.0 and 13.2 mg/m3, respectively, and 0.7 and 1.0 mg/m3 among low exposed. High exposed workers had more acute cough, shortness of breath and stuffy nose than the low exposed. Mean percentage cross-shift decrease in PEF was significantly more pronounced among high exposed workers than low exposed (95% CI 1.1, 6.1%). For workers with concurrent respirable dust, PEF and questionnaire assessment, an exposure–response relationship was found between log-transformed respirable dust and percentage cross-shift decrease in PEF (4.5% per unit of log-respirable dust in mg/m3 ; 95% CI 3.3, 5.6%). Respirable dust exposure ≥2.0 mg/m3 versus <2.0 mg/m3 was associated with increased prevalence ratio for cough (7.9) and shortness of breath (4.2). Shortness of breath was associated with the highest sensitivity (0.87) and specificity (0.83) for diagnosing a percentage cross-shift decrease in PEF of ≥10%. Conclusion: The observed acute respiratory health effects among the workers are most likely due to exposure to high concentrations of irritant cement dust. The results also highlight the usefulness of the questionnaire for health surveillance of the acute respiratory health effect.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Abou-Taleb AN, Musaiger AO, Abdelmoneim RB (1995) Health status of cement workers in the United Arab Emirates. J R Soc Health 115(6):378–381
Abrons HL, Petersen MR, Sanderson WT, Engelberg AL, Harber P (1988) Respiratory symptoms, ventilatory function, and environmental exposures in Portland cement workers. Br J Ind Med 45:368–375
Abrons HL, Petersen MR, Sanderson WT, Engelberg AL, Harber P (1997) Chest radiography in Portland cement workers. J Occup Environ Med 39(11):1047–1054
AbuDhaise BA, Rabi AZ, Al Zwairy MA, El Hader AF, El Qaderi S (1997) Pulmonary manifestations in cement workers in Jordan. Int J Occup Med Environ Health 10(4):417–428
Alakija W, Iyawe VI, Jarikre LN, Chiwuzie JC (1990) Ventilatory function of workers at Okpella cement factory in Nigeria. West Afr J Med 9(3):187–192
Ali BA, Ballal SG, Albar AA, Ahmed HO (1998) Post-shift changes in pulmonary function in a cement factory in eastern Saudi Arabia. Occup Med 48(8):519–522
Alvear Galindo MG, Mendez-Ramirez I, Villegas-Rodriguez JA et al (1999) Risk indicator of dust exposure and health effects in cement plant workers. J Occup Environ Med 41(8):654–661
American Conference of Governmental Industrial Hygienists (ACGIH) (2000) Threshold limit values for chemical substances and physical agents and biological exposure indices. Cincinnati, OH: ACGIH, pp 15–76
Bohadana AB, Massin N, Teculescu D, Peslin R (1994) Tracheal wheezes during metacholine airway challenge (MAC) in workers exposed to occupational hazards. Respir Med 88(8):581–587
British Medical Research Council’s committee (BMRC) (1960) Standardised questionnaire on respiratory symptoms. Br Med J 2:1665
Burge PS (1997) The relationship between peak expiratory flow and respiratory symptoms. Eur Respir J 10(suppl 24):67s–68s
Dietz A, Ramroth H, Urban T, Ahrens W, Becher H (2004) Exposure to cement dust, related occupational groups and laryngeal cancer risk: results of a population based case-control study. Int J Cancer 108:907–911
Encyclopaedia of occupational health and safety (1999) 4th edn, vol 3. International Labour Organization, Geneva, pp 93.44–93.46
Fairhurst S, Phillips A, Gilles C, Brown RH (1997) Portland cement dust: criteria document for an occupational exposure limit. Health and Safety Executive, London
Fell AK, Thomassen TR, Kristensen P et al (2003). Respiratory symptoms and ventilatory function in workers exposed to Portland cement dust. J Occup Environ Med 45(9):1008–1014
Hauser R, Daskalakis C, Christiani D (1996) A regression approach to the analysis of serial peak flow among fuel oil ash exposed workers. Am J Respir Crit Care Med 154:974–980
Hennekens CH, Buring JE (1987) Epidemiology in Medicine, 1st edn. Little, Brown and co., USA, pp 331–345
Jakobsson K, Horstmann V, Welinder H (1993) Mortality and cancer morbidity among cement workers. Br J Ind Med 50(3):264–272
Lebowitz MD, Krzyzanowski M, Quackenboss JJ, O’Rourk MK (1997) Diurnal variation of PEF and its use in epidemiological studies. Eur Respir J 24(suppl):49s–56s
Massin N, Moulin JJ, Wild P et al (1991) A study of the prevalence of acute respiratory disorders among workers in the textile industry. Int Arch Occup Environ Health 62(8):555–560
Mengesha YA, Bekele A (1997) Effects of acute exposure to different occupational dusts on pulmonary function indices of factory workers in Ethiopia. Afr Newslett Occup Health Saf 7:8–9
National Institute for Occupational Safety and Health (NIOSH) (1998) Manual of Analytical Methods. Silica, Crystalline, by XRD Method 7500, 4th edn. Cincinnati, NIOSH
Noor H, Yap CL, Zolkepli O, Faridah M (2000) Effects of exposure to dust on lung function of cement factory workers. Med J Malaysia 55(1):51–57
Oleru UG (1984) Pulmonary function and symptoms of Nigerian workers exposed to cement dust. Environ Res 33:379–385
Robins T, Seixas N, Franzblau A et al (1997) Acute respiratory effects on workers exposed to Metalworking fluid aerosol in an automotive transmission plant. Am J Ind Med 31:510–524
Thomson ML, Myers JE, Kriebel D (1998) Prevalence odds ratio or prevalence ratio in the analysis of cross sectional data: what is to be done? Occup Environ Med 55: 272–277
Ulvestad B, Bakke B, Eduard W, Kongerud J, Lund MB (2001) Cumulative exposure to dust causes accelerated decline in lung function in tunnel workers. Occup Environ Med 58:663–669
Vestbo J, Rasmussen FV (1990) Long-term exposure to cement dust and later hospitalisation due to respiratory disease. Int Arch Occup Environ Health 62(3):217–220
Wasserfallen JB, Gold K, Schulman KA, Baraniuk JN (1997) Development and validation of a rhinoconjuctivitis and asthma symptom score for use as an outcome measure in clinical trials. J Allergy Clin Immunol 100(1):16–22
Yang CY, Huang CC, Chiu HF, Chiu JF, Lan SJ, Ko YC (1996) Effects of occupational dust exposure on the respiratory health of Portland cement workers. J Toxicol Environ Health 49:581–588
Zock JP, Heederik D, Brunekreef B (1999) Influence of shift work and host factors on endotoxin-related acute peak flow changes. Am J Respir Crit Care Med 159:137–142
Acknowledgments
We thank the Tanzania Portland Cement factory management and the workers for their cooperation and participation in the study. This study was financed by the Norwegian State Education Loan Fund (Staten Lånekassen) and the University of Bergen.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Mwaiselage, J., Moen, B. & Bråtveit, M. Acute respiratory health effects among cement factory workers in Tanzania: an evaluation of a simple health surveillance tool. Int Arch Occup Environ Health 79, 49–56 (2006). https://doi.org/10.1007/s00420-005-0019-x
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00420-005-0019-x